update - Page 4 : Suzuki GSX-R Motorcycle Forums: Gixxer.com
» Insurance
» Suzuki GSX-R Prices
» Sponsors
Go Back   Suzuki GSX-R Motorcycle Forums Gixxer.com > Gixxer Forums > Water Cooled Gixxers

Reply
 
Thread Tools Display Modes
Old 10-30-2012, 10:10 PM   #61
Sabba
Club Racer
 
Sabba's Avatar
 
Join Date: Jun 2009
Location: Victoria, Canada
Motorcycle: '89 CBR 600 (SOLD), '93 GSXR 750 (SOLD), '04 GSXR 600
Posts: 3,052
Re: update

Quote:
Originally Posted by cody5127 View Post
blew cleaner through the, idle (?) Jet, the one that comes out on the float sides
A little confused by this statement...your idle (or pilot) jet is the one shown in the picture.

Other than that, sounds like you're good to go
Attached Images
File Type: jpg 101_4190.jpg (60.0 KB, 75 views)
Sabba is offline   Reply With Quote
Sponsored Links
Advertisement
 
Old 10-31-2012, 05:27 AM   #62
cody5127
Rookie
 
cody5127's Avatar
 
Join Date: Aug 2012
Location: Des Moines Iowa
Motorcycle: 1995 gixxer 750
Posts: 269
Re: update

My bad, pilot jet. Like I've said before, I don't know shit about carbs
cody5127 is offline   Reply With Quote
Old 10-31-2012, 03:21 PM   #63
cody5127
Rookie
 
cody5127's Avatar
 
Join Date: Aug 2012
Location: Des Moines Iowa
Motorcycle: 1995 gixxer 750
Posts: 269
Re: update

I an going to be seriously disappointed if this doesn't fix anything... I'm going out tomorrow after work to install. I'll give an update then.
cody5127 is offline   Reply With Quote
Old 11-02-2012, 06:02 AM   #64
cody5127
Rookie
 
cody5127's Avatar
 
Join Date: Aug 2012
Location: Des Moines Iowa
Motorcycle: 1995 gixxer 750
Posts: 269
Ok, update... Ran great for about half hour then started sputtering and eventually died, but last glance the fuel lines were dry. And yes there was gas about two gallons. Took off petcock looks to be ok. When I had the tank off no fuel came out even on prime

Sent from my EVO using Motorcycle.com Free App

Last edited by cody5127; 11-02-2012 at 06:21 AM.
cody5127 is offline   Reply With Quote
Old 11-02-2012, 10:01 AM   #65
Sabba
Club Racer
 
Sabba's Avatar
 
Join Date: Jun 2009
Location: Victoria, Canada
Motorcycle: '89 CBR 600 (SOLD), '93 GSXR 750 (SOLD), '04 GSXR 600
Posts: 3,052
Re: update

Fuel should flow freely from the PRIME position.

In the ON or RES position, no fuel should flow unless vacuum is applied to the vacuum outlet...
Sabba is offline   Reply With Quote
Old 11-02-2012, 10:04 AM   #66
cody5127
Rookie
 
cody5127's Avatar
 
Join Date: Aug 2012
Location: Des Moines Iowa
Motorcycle: 1995 gixxer 750
Posts: 269
Re: update

So what usually causes this issue? Replace petcock?
cody5127 is offline   Reply With Quote
Old 11-02-2012, 06:25 PM   #67
cody5127
Rookie
 
cody5127's Avatar
 
Join Date: Aug 2012
Location: Des Moines Iowa
Motorcycle: 1995 gixxer 750
Posts: 269
Petcock all tore apart...

Sent from my EVO using Motorcycle.com Free App
Attached Images
File Type: jpg uploadfromtaptalk1351898683578.jpg (14.4 KB, 47 views)
File Type: jpg uploadfromtaptalk1351898693820.jpg (18.5 KB, 47 views)
File Type: jpg uploadfromtaptalk1351898708052.jpg (17.3 KB, 47 views)
cody5127 is offline   Reply With Quote
Old 11-02-2012, 08:24 PM   #68
Adamm Bomb
Lifetime Premium
 
Adamm Bomb's Avatar
 
Join Date: Jun 2011
Location: Hamilton Ontario
Motorcycle: 1995 Gsx-r 750
Posts: 77
Re: update

I would buy a new pingle valve or a rebuild kit. That diaphragm looks terrible, which could be an indication that the rest of the seals are in bad shape. I just purchase a new rebuild kit for $30 off of a local shop.
Adamm Bomb is offline   Reply With Quote
Old 11-02-2012, 08:30 PM   #69
cody5127
Rookie
 
cody5127's Avatar
 
Join Date: Aug 2012
Location: Des Moines Iowa
Motorcycle: 1995 gixxer 750
Posts: 269
Isn't the plastic in the middle of the valve shot? our am I thinking of something else that breaks with our valves?

from my EVO using Motorcycle.com Free App
cody5127 is offline   Reply With Quote
Old 11-02-2012, 08:31 PM   #70
cody5127
Rookie
 
cody5127's Avatar
 
Join Date: Aug 2012
Location: Des Moines Iowa
Motorcycle: 1995 gixxer 750
Posts: 269
And all of the o rings look to be in great shape, no cracks or signs of wear

Sent from my EVO using Motorcycle.com Free App
cody5127 is offline   Reply With Quote
Old 11-03-2012, 01:06 AM   #71
Sabba
Club Racer
 
Sabba's Avatar
 
Join Date: Jun 2009
Location: Victoria, Canada
Motorcycle: '89 CBR 600 (SOLD), '93 GSXR 750 (SOLD), '04 GSXR 600
Posts: 3,052
Re: update

The plastic piece is known to seize up...

The metal prongs from the handle piece then snap off if you try to turn it (happened on mine)...terrible design. If your petcock is in fact shot, get a Pingle as mentioned above. The part # should be in a sticky in this forum...

Why don't you try rigging up an auxillary tank to see how she runs?
Sabba is offline   Reply With Quote
Old 11-03-2012, 09:46 AM   #72
cody5127
Rookie
 
cody5127's Avatar
 
Join Date: Aug 2012
Location: Des Moines Iowa
Motorcycle: 1995 gixxer 750
Posts: 269
Talking about the tabs on this? Our where they should be?

Sent from my EVO using Motorcycle.com Free App
Attached Images
File Type: jpg uploadfromtaptalk1351953992129.jpg (15.8 KB, 47 views)
cody5127 is offline   Reply With Quote
Old 11-03-2012, 11:16 AM   #73
Adamm Bomb
Lifetime Premium
 
Adamm Bomb's Avatar
 
Join Date: Jun 2011
Location: Hamilton Ontario
Motorcycle: 1995 Gsx-r 750
Posts: 77
Re: update

Can't really see them from the size of the pic. But yes at the base of that pin there should be two metal tabs. They almost look to be broken, in that case a replacement petcock is needed.
Adamm Bomb is offline   Reply With Quote
Old 11-03-2012, 12:04 PM   #74
cody5127
Rookie
 
cody5127's Avatar
 
Join Date: Aug 2012
Location: Des Moines Iowa
Motorcycle: 1995 gixxer 750
Posts: 269
Re: update

what would a pingle run me, with the base and valve, i cant seem to find anything on my phone.
cody5127 is offline   Reply With Quote
Old 11-03-2012, 12:05 PM   #75
cody5127
Rookie
 
cody5127's Avatar
 
Join Date: Aug 2012
Location: Des Moines Iowa
Motorcycle: 1995 gixxer 750
Posts: 269
Re: update

and no stealerships
cody5127 is offline   Reply With Quote
Old 11-03-2012, 03:02 PM   #76
contagious
Back Marker
 
contagious's Avatar
 
Join Date: Jul 2012
Location: Nova Scotia, Canada
Motorcycle: 1995 GSXR750W
Posts: 131
Cody i just ordered a pingel and the adaptor for 108 Canadian shipping and taxes included from a seller on ebay.

Sent from my SGH-I727R using Motorcycle.com Free App
contagious is offline   Reply With Quote
Old 11-03-2012, 03:54 PM   #77
cody5127
Rookie
 
cody5127's Avatar
 
Join Date: Aug 2012
Location: Des Moines Iowa
Motorcycle: 1995 gixxer 750
Posts: 269
Re: update

I don't have an Ebay account, let alone a bank account. Haven't had one for about for years or so. Don't need one when all my money is gone to bills as soon as I cash my checks.
cody5127 is offline   Reply With Quote
Old 11-03-2012, 03:59 PM   #78
berencam
Rookie
 
berencam's Avatar
 
Join Date: Apr 2011
Location: Central Arkansas
Motorcycle: 07 gsxr 600
Posts: 1,394
Paypal loadable cards, and ebay.
berencam is offline   Reply With Quote
Old 11-03-2012, 04:01 PM   #79
cody5127
Rookie
 
cody5127's Avatar
 
Join Date: Aug 2012
Location: Des Moines Iowa
Motorcycle: 1995 gixxer 750
Posts: 269
Re: update

That's great, but still no money, just gotta save up what I can.
cody5127 is offline   Reply With Quote
Sponsored Links
Advertisement
 
Reply

Thread Tools
Display Modes

Posting Rules
You may not post new threads
You may not post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is Off

Forum Jump

Powered by vBadvanced CMPS v3.2.2

All times are GMT -5. The time now is 07:23 AM.



Powered by vBulletin® Copyright ©2000 - 2014, Jelsoft Enterprises Ltd.
Copyright 2008 2013 Gixxer.com
Motorcycle News, Videos and Reviews
Honda Grom Forum Harley Davidson Forum Honda 600RR Kawasaki Forum Yamaha R6 Forum Yamaha FZ-09 Forum
1199 Panigale Forum Roadglide Forum Honda CBR1000 Forum Vulcan Forum Yamaha R1 Forum Yamaha R3 Forum
Ducati Monster Forum Harley Forums Honda CBR250R Forum ZX10R Forum Star Raider Forum Yamaha Viking Forum
Suzuki GSXR Forum V-Rod Forums Honda Shadow Forum Kawasaki Motorcycle Forum Star Warrior Forum KTM Duke 390 Forum
SV650 Forum BMW S1000RR Forum Honda Fury Forum Kawasaki Versys Forum Drag Racing Forum Ducati 899 Panigale Forum
Suzuki V-Strom BMW K1600 Triumph Forum Victory Forums Sportbikes BMW NineT Forum
Volusia Forum BMW F800 Forum Triumph 675 Forum MV Agusta Forum HD Street Forum Suzuki GW250 Forum
Yamaha Motorcycles Victory Gunner Forum Honda Vultus Forum HD LiveWire Forum